Jun 15, 2015 · Reattach the power steering pump pulley. Step 9 – Re-install the removed components. Attach the hydraulic power steering supply and return lines. Install and correctly route the drive belt. Attach the radiator fan and fan shroud. Install the air duct. Reconnect the negative (black) battery terminal. Step 10 – Add fluid to the power steering ...

Jun 26, 2015 · Let it cycle for a few seconds and check the power steering fluid level, adding more if necessary. Then cycle the power steering from lock to lock a few times; this will help push out any air bubbles. Put the power steering fluid reservoir cap back on, and take the truck out for a spin. After about 20 minutes, check the fluid level again.

Jun 24, 2015 · Step 1 – Remove power steering reservoir cap. Open your hood and locate the power steering fluid reservoir. Open the cap on the reservoir and set it aside somewhere safe. Figure 1. Power steering fluid reservoir. Step 2 – Drain power steering fluid from the reservoir. There are three ways to do this:

Jun 24, 2015 · Reconnect the power steering lines, and re-install the lower fan shroud. Reattach the fan to the water pump. Rotate the fan clockwise, and then tighten the nut to a snug fit. Reconnect the air inlet hoses and tighten the clamps. Check your power steering fluid level and top off as needed. Figure 4. Check power steering fluid level after the ...

Apr 23, 2018 · Component Name: STEERING: ELECTRIC POWER ASSIST SYSTEM. MFRCOMPONENTSYSTEM: N/A. MFRCOMPONENTSUBSYSTEM: N/A. Summary: This Preliminary Information communication provides information to the technician about vehicles that have a hydraulic rush or flow type noise from the power steering gear. Dealer should …

Read expert Chevrolet Silverado 1500 steering and suspension problem guides and repair how to's with photos and videos to help you maintain your Chevrolet truck

Apr 5, 2017 · 1999 - 2006 (GMT800) - Power steering leak - Hi and thanks in advance for any help. So I have 2001 Silverado 1500 and my serpentine belt and power steering pump and high pressure line all needed to be replaced because leaking power steering fluid everywhere and impossible to steer.

Apr 27, 2009 · 10. Now you will need to remove the lower steering column cover. Start by removing the two torque screws with a letter "V" torque driver on the bottom side of the steering column (10-1). Next, remove the tilt adjustment button, if equipped, by pulling the lever perpendicular to steering column (10-2).

Apr 4, 2014 · the driver may experience a sudden loss of power steering assist that could occur at any time while driving. consequence: if power steering assist is lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash. remedy: dealers will replace the electric power steering motor free of charge. owners are being ...

Dec 12, 2024 · RECORD_ID: 5054516. NHTSA Item Number: 11011805. Replacement Service Bulletin Number: N/A. Date Added: Dec 12, 2024 ...